VOLKSWAGEN JETTA TRANSMISSION AN

VOLKSWAGEN JETTA TRANSMISSION AND POWERTRAIN PROBLEMS

Volkswagen Jetta owners have complained of transmission, clutch problems, hesitation, and other issues. Owners with problems may be entitled to compensation for inconvenience or diminished value.

Component: POWER TRAIN:AUTOMATIC TRANSMISSION

Details: MY 2006 JETTA 2.5 HAS AN INTERMITTENT ACCELERATOR HESITATION. IT CAN OCCUR WHEN THE ENGINE IS COLD OR HOT. IT SEEMS TO OCCUR WHEN IT IS ROLLING FREE AT NEAR 5 TO 10 MPH, AND WHEN THE ACCELERATOR IS PRESSED NOTHING HAPPENS FOR A SECOND OR TWO. THEN IT CATCHES AND GOES. *TR

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10233159

Component: POWER TRAIN:MANUAL TRANSMISSION

Details: MY CAR BEGAN LEAKING OIL AFTER LAST CHANGE AT BERT SMITH VOLKSWAGEN IN ST. PETERSBURG FLORIDA. CHECKED UNDERNEATH CAR AND FOUND TRANSMISSION CASING AND FLYWHEEL HOUSING CRACKED. TOOK PICTURES BUT ACCORDING TO BERT SMITH VOLKSWAGEN THIS IS JUST DIRT AND GREASE STAINS, THEY CANNOT SHOW ME ANOTHER CAR WITH THE SAME "STAINS". *TR

Occurrences: 1 Injuries: 0
Fail Date: 07/03/2008 Deaths: 0
Date added to datbase: 7/3/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10231339

Component: POWER TRAIN:MANUAL TRANSMISSION

Details: CLUTCH FAILURE ON 2006 JETTA TDI CLUTCH FAILED WHILE DRIVING REPAIR OF CLUTCH BY OWNER, DEALER REFUSED TO REPAIR. *TR

Occurrences: 1 Injuries: 0
Fail Date: 06/09/2008 Deaths: 0
Date added to datbase: 6/17/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10229671

Component: POWER TRAIN:MANUAL TRANSMISSION

Details: NOTICED VERY ROUGH IDLE. DEALER DIAGNOSED MANUAL TRANSMISSION FLYWHEEL MALFUNCTIONING WITHOUT VISUAL INSPECTION. THE FAULT WAS PLACED WITH ME. WEAR AND TEAR. DEALER CLAIMED MUST FIX, NOT SAFE TO DRIVE, QUOTED $2100. IF THIS PROBLEM IS ALLOWED TO WORSEN, THE FAILURE MODE IS A COMPLETE CLUTCH FAILURE AND ON A BUSY FREEWAY IS A SERIOUS SAFETY ISSUE. I WENT TO A THIRD PARTY GARAGE AND PAID $1200 FOR A MORE RELIABLE SINGLE MASS FLYWHEEL. THE DAMAGED SACHS DMF IS AVAILABLE FOR INSPECTION. *TR

Occurrences: 1 Injuries: 0
Fail Date: 04/15/2008 Deaths: 0
Date added to datbase: 6/2/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10227671

Component: POWER TRAIN:AUTOMATIC TRANSMISSION

Details: AT TEMPERATURES LESS THAN 15 DEGREES FAHRENHEIT, MY 2006 VOLKSWAGEN JETTA TDI WITH DSG TRANSMISSION SURGES FORWARD UPON STARTING. THIS SURGE HAPPENS IF THE CAR IS IN PARK (P) OR NEUTRAL (N). THE SURGE IS NOTICEABLE EVEN WITH THE PARKING BRAKE SET AND STANDARD BRAKING SYSTEM APPLIED. THIS SURGE DOES NOT ALLOW THE CAR TO START NORMALLY (E.G. STALLS THE ENGINE). THE SURGE HAPPENS ONLY ONCE DURING A COLD START. AFTERWARD, THE CAR STARTS AND RUNS NORMALLY. *TR

Occurrences: 1 Injuries: 0
Fail Date: 01/15/2008 Deaths: 0
Date added to datbase: 5/13/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10227348

Component: POWER TRAIN:CLUTCH ASSEMBLY

Details: LETTER FROM SENATOR ON BEHALF OF CONSTITUENT, REGARDING HIS CONCERNS WITH THE 2006 VOLKSWAGEN JETTA. *NJ THE CONSUMER STATED THE CLUTCH STARTED SLIPPING. THE DEALER INFORMED THE CONSUMER THAT THE 5-SPEED VEHICLES WERE MADE WITH A DEFECTIVE CLUTCH PLATE, BUT THE TRANSMISSION WOULD HAVE TO BE REMOVED TO DETERMINE IF THE VEHICLE HAD THE DEFECTIVE PART. THE DEALER STATED IF THE VEHICLE DID NOT HAVE THE DEFECTIVE PART, THE CONSUMER WOULD BE CHARGED $500 IN LABOR FEES FOR REMOVING THE TRANSMISSION. *JB

Occurrences: 1 Injuries: 0
Fail Date: 05/01/2008 Deaths: 0
Date added to datbase: 5/8/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10227184

Component: POWER TRAIN:MANUAL TRANSMISSION

Details: ENGINE FAILURE ON MY 2006 VOLKSWAGEN DIESEL JETTA. THE ELECTRONIC CONTROL FUEL INJECTOR OVER FUELED THE CYLINDERS AND CAUSED THE PULL RODS TO BEND AND DAMAGED THE ENGINE, COSTS ARE $7,500 TO REPAIR THE ENGINE. CAR IS ONLY 2 AND HALF YEARS OLD WITH 85,0000 MILES. *TR

Occurrences: 1 Injuries: 0
Fail Date: 03/09/2008 Deaths: 0
Date added to datbase: 5/9/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10226942

Component: POWER TRAIN:MANUAL TRANSMISSION

Details: VOLKSWAGEN JETTA TDI - VW REFUSED TO HONOR THE WARRANTY OF A DEFECTIVE CLUTCH/FLYWHEEL ISSUE. THIS IS A VERY COMMON OCCURANCE APPARENTLY. I LEARNED OF THIS WHEN I WENT ONLINE TO DO SOME RESEARCH ABOUT THE PROBLEM. VOLKSWAGEN IS HONORING THE WARRANTIES IN EUROPE WITH THE SAME ISSUE BUT IGNORING ITS QUALITY / SAFETY ISSUE HERE IN THE US. THE DEFECTIVE CLUTCH / FLYWHEEL ISSUE CAN CAUSE SERIOUS INJURY AND OR DEATH WHEN THE FLYWHEEL DISENTIGRATES. *TR

Occurrences: 1 Injuries: 0
Fail Date: 03/06/2008 Deaths: 0
Date added to datbase: 5/7/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10225837

Component: POWER TRAIN:DRIVELINE

Details: PREMATURE FAILURE OF CLUTCH. *TR

Occurrences: 1 Injuries: 0
Fail Date: 04/20/2008 Deaths: 0
Date added to datbase: 4/27/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10225010

Component: POWER TRAIN:CLUTCH ASSEMBLY

Details: MY 2006 VW JETTA TDI CLUTCH WENT OUT WHILE DRIVING ON THE HIGHWAY. THE CLUTCH WAS DEPRESSED ALL THE WAY TO THE FLOOR AND WOULD NOT COME BACK UP. I PULLED IT BACK UP AND IT WOULD NOT GO BACK DOWN. CLUTCH WAS NEVER SPONGY BEFOREHAND AND JUST WENT OUT WITH NO PRIOR INDICATION OF A PROBLEM. CALLED THE DEALERSHIP AND THEY SAID IT WAS NOT COVERED UNDER WARRANTY (CAR HAS APPROX 40,000 MILES). AFTER DOING RESEARCH AND FINDING OUT OTHERS HAVE SAME PROBLEM I WILL BE COMPLAINING TO DEALERSHIP TO HAVE IT COVERED. I AM A STUDENT AND MY HUSBAND IS IN THE ARMY WE DON'T HAVE $2000 TO PAY FOR SUCH A REPAIR, THAT WAS NOT CAUSED BY "NORMAL WEAR AND TEAR". *TR

Occurrences: 1 Injuries: 0
Fail Date: 04/19/2008 Deaths: 0
Date added to datbase: 4/19/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10223831

Component: POWER TRAIN:CLUTCH ASSEMBLY

Details: I AM THE OWNER OF A 2006 VOLKSWAGEN JETTA TDI 5-SPEED WITH 39,000 MILES. MY VEHICLE WAS MANUFACTURED IN MEXICO IN JANUARY OF 2006, AND I PURCHASED IT IN JUNE OF 2006. THIS WEEK, THE CLUTCH STARTED SLIPPING AND IT WARRANTED A VISIT TO THE LOCAL VW DEALERSHIP SERVICE DEPARTMENT. THE SERVICE DEPARTMENT INFORMED ME THAT MANY 2006 VW JETTA TDI 5-SPD VEHICLES WERE MADE WITH A DEFECTIVE CLUTCH PLATE, BUT THEY WOULD HAVE TO REMOVE MY TRANSMISSION TO DETERMINE WHETHER OR NOT MY VEHICLE HAD THE DEFECTIVE PART. THEY INFORMED ME THAT IF MY VEHICLE DID NOT HAVE THE DEFECTIVE PART, THEY WOULD CHARGE ME NEARLY $500 IN LABOR FEES FOR REMOVING THE TRANSMISSION FOR INSPECTION. I SHOULD NOT HAVE TO PAY TO HAVE MY VEHICLE INSPECTED TO DETERMINE WHETHER IT HAS THE DEFECTIVE PART, NOR SHOULD I HAVE TO DRIVE MY VEHICLE WHEN THIS CLUTCH HAS BEEN FAILING PREMATURELY. UPON FURTHER INVESTIGATION, I FOUND NUMEROUS COMPLAINTS ABOUT THIS CLUTCH PLATE ON THE NHTSA WEBSITE. I ALSO FOUND 88 PAGES ON ONE FORUM ALONE (HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=137014) ABOUT THIS PART AND THE CLUTCH/FLYWHEEL ASSEMBLY FAILING PREMATURELY. MANY OF THESE PEOPLE WERE FORCED TO PAY FOR A NEW CLUTCH AT A COST OF OVER $2000.00. SOME WERE REPLACED UNDER WARRANTY. THIS CLUTCH PLATE AND THE CORRESPONDING ASSEMBLY HAS BEEN RECALLED BECAUSE OF SAFETY CONCERNS IN MANY COUNTRIES EXCEPT FOR THE UNITED STATES. I FEAR HAVING MY CLUTCH FAIL WHEN I NEED THE ENGINE TO BE ENGAGED. IF I WERE TO HAVE A SUDDEN LOSS OF POWER, IT COULD EASILY CAUSE AN ACCIDENT AND ENDANGER MYSELF AND THE OCCUPANTS OF MY VEHICLE. IS THERE ANYTHING THAT CAN BE DONE TO BRING THIS PROBLEM TO THE SURFACE, AND PROMPT AN INVESTIGATION BY THE NHTSA TO LOOK INTO THIS KNOWN SAFETY ISSUE? THESE DEFECTIVE PARTS NEED TO BE RECALLED AT NO COST TO THE CONSUMER. IT SEEMS THAT NHTSA IS IGNORING THIS MATTER AT THE CONSUMER'S EXPENSE, AND THE AUTOMAKERS BENEFIT. *TR

Occurrences: 1 Injuries: 0
Fail Date: 04/08/2008 Deaths: 0
Date added to datbase: 4/9/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10221621

Component: POWER TRAIN:CLUTCH ASSEMBLY

Details: 2006 JETTA TDI. DMF AND CLUTCH FAILURE AFTER 54,000 MI OF NORMAL DRIVING. CAR STUCK IN GEAR WHILE DRIVING, UNABLE TO STOP AND GO. NOT COVERED UNDER EXTENDED WARRANTY. DESCRIBED AS NORMAL WEAR AND TEAR. CHEAP DUAL MASS FLYWHEEL AND CLUTCH COMPONENTS! *TR

Occurrences: 1 Injuries: 0
Fail Date: 03/17/2008 Deaths: 0
Date added to datbase: 3/18/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10219244

Component: POWER TRAIN:CLUTCH ASSEMBLY

Details: I RECENTLY PURCHASED A 2006 VW TDI USED, WITH 33K MILES. AFTER ONE DAY OF OWNERSHIP THE CLUTCH PEDAL WENT THE FLOOR. I PULLED THE PEDAL UP WITH MY TOE, AND GOT IT TO ENGAGE ONE MORE TIME, THEN BACK TO THE FLOOR. AFTER THAT, THE CAR WOULDN'T PULL ITSELF IN ANY GEAR. THE CAR NEVER SLIPPED, VIBRATED, ETC., NO SYMPTOMS OF A WORE CLUTCH, JUST INSTANT FAILURE. I CALLED VW ROADSIDE ASSISTANCE, AND VW TOWED IT TO A DEALER 3HOURS AWAY. BEFORE THE DEALER TORE INTO IT THEY CALLED ME AND SAID THAT IF IT IS DUE TO CLUTCH WEAR/ABUSE THAT IT WOULD NOT BE COVERED. AFTER SOME RESEARCH HERE ON TDICLUB, I FOUND THAT DMF, AND CLUTCH FAILURES WERE VERY COMMON AND GENERALLY WARRANTED. I TOLD THE DEALER TO GO AHEAD AND TEAR INTO THE CAR TO FIND OUT MORE. TODAY I GET A CALL AND THEY TELL ME THAT THE CLUTCH IS WORE OUT, AND THAT IT IS NOT COVERED. THE ADVISOR ON THE PHONE SAID THAT HALF THE CLUTCH ON ONE SIDE IS ALMOST COMPLETELY GONE, AND THE OTHER SIDE IS COMPLETELY GONE. AND IF I COME PICK IT NOW, I WILL ONLY BE OUT $550, OR I CAN HAVE THEM DO THE REPAIR FOR $1800. I TOLD HIM TO NOT DO ANYTHING YET, AND THAT I WOULD CALL HIM BACK TOMORROW WITH AN ANSWER. THE SERVICE ADVISOR WAS VERY NICE, AND AS HELPFUL AS HE COULD BE, BUT COULD NOT WARRANTY THE CLUTCH OR REPAIR. *TR

Occurrences: 1 Injuries: 0
Fail Date: 02/21/2008 Deaths: 0
Date added to datbase: 2/26/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10215447

Component: POWER TRAIN:CLUTCH ASSEMBLY

Details: NO SYMPTOMS PRIOR TO FAILURE. WHILE EXITING FREEWAY, CLUTCH STOPPED OPERATING BETWEEN GEARS, WHILE DOWNSHIFTING. COULD NOT GET CAR BACK INTO GEAR AND HAD TO STOP IN MIDDLE OF MULTI LANE OFFRAMP, POINTING SLIGHTLY UPHILL. CLUTCH PEDAL WOULD COME ONLY HALF WAY UP. CLUTCH COULD NOT BE ENGAGED ENOUGH TO START ENGINE. AAA WAS CALLED AND ARRIVED AFTER 20 MINUTES, DURING WHICH TIME CAR REMAINED IN OFFRAMP. CAR WAS TOWED TO DEALER AND LEFT OVER LONG NEW YEAR'S WEEKEND. DEALER SERVICE DEPARTMENT INFORMED ME, ONCE THEY LOOKED AT IT, THAT THE CLUTCH HAD FAILED AND THAT I WOULD HAVE TO PAY FOR IT AS IT WAS OUT OF WARRANTY. I AGREED TO THE SERVICE SINCE THIS IS MY ONLY VEHICLE. I WAS CHARGED $1,863. FOR THE SERVICE, WHICH INCLUDED REPLACEMENT OF THE FLYWHEEL. I COMPLAINED THAT THE FLYWHEEL WAS PART OF THE ENGINE, AND SHOULD BE COVERED UNDER WARRANTY. I WAS DIRECTED TO CALL VOLKSWAGEN AND SUBMIT A COMPLAINT. I ASKED TO RETAIN THE PARTS SO THAT I COULD SEE WHAT HAD GONE WRONG. THE NEXT DAY, BEFORE CALLING VOLKSWAGEN, I DISCOVERED FROM AN INDEPENDENT SOURCE THAT VOLKSWAGEN HAS HAD A TECHNICAL SERVICE BULLETIN OUT ON THE CLUTCH SINCE NOVEMBER 2007. AFTER VERIFYING FROM THE PARTS THAT I WAS COVERED, I INFORMED THE DEALERSHIP. I HAVE BEEN TOLD THEY ARE CUTTING ME A CHECK TO REPAY WHAT I SPENT ON THE REPLACEMENT. *TR

Occurrences: 1 Injuries: 0
Fail Date: 12/29/2007 Deaths: 0
Date added to datbase: 1/19/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10215407

Component: POWER TRAIN:CLUTCH ASSEMBLY

Details: WAS EXITING THE HIGHWAY AND DEPRESSED THE CLUTCH. THE CLUTCH WENT TO THE FLOOR AND I WAS UNABLE TO SHIFT GEARS. I WAS ABLE TO GET THE VEHICLE IN NEUTRAL AND GET TO THE SIDE OF THE ROAD. I HAVE LEARNED THIS IS A COMMON PROBLEM WITH PREMATURE FAILURE OF CLUTCHES ON 2006 VOLKSWAGEN JETTA TDIS. *TR

Occurrences: 1 Injuries: 0
Fail Date: 01/15/2008 Deaths: 0
Date added to datbase: 1/19/2008

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10210256

Component: POWER TRAIN:CLUTCH ASSEMBLY

Details: I PURCHASED A BRAND NEW 2006 JETTA TDI (STANDARD SHIFT); AT THE TIME OF THIS INCIDENT THE VEHICLE HAD APPROX. 17,000 MILES ON IT. I WAS DRIVING ON THE HIGHWAY AND UPON DOWNSHIFTING THE CLUTCH FAILED AND THE VEHICLE WAS STUCK IN GEAR; I WAS UNABLE TO TAKE THE CAR OUT OF GEAR OR CHANGE SPEED. THIS INCIDENT LED ME TO HAVE TO DRIVE THE VEHICLE OFF TO THE SIDE OF THE HIGHWAY WHILE BEING UNABLE TO SAFELY CONTROL THE VEHICLE. UPON FURTHER INVESTIGATION IT APPEARS THAT THIS HAS BEEN A COMMON PROBLEM WITH SACHS CLUTCHES FROM VOLKSWAGEN. CLEARLY, WITHOUT A RECALL, THIS IS PUTS MANY DRIVERS IN AN EXTREMELY UNSAFE SITUATION. THE DEALER REPAIRED THIS PROBLEM FOR NO COST; HOWEVER, THEY WERE UNAWARE THAT THIS PROBLEM IS COMMON AND THAT VW HAS RECENTLY RELEASED A SERVICE BULLETIN REGARDING THE FAILING CLUTCHES. A RECALL IS THE ANSWER; HOWEVER, VW SO FAR HAS NOT HAD TO ISSUE ONE. *TR

Occurrences: 1 Injuries: 0
Fail Date: 11/16/2007 Deaths: 0
Date added to datbase: 11/28/2007

Volkswagen Jetta powertrain problem, defect, flywheel, clutch problem, Volkswagen Jetta class action, lemon law, Volkswagen Jetta defect

CONSUMER COMPLAINT: ODI Case Number: 10202780

Component: POWER TRAIN:CLUTCH ASSEMBLY

Details: JUST HAD THE DUAL MASS FLYWHEEL AND CLUTCH REPLACED @ 40,000 MILES WHICH IS CRAZY. CLUTCH WAS SLIPPING AND AFTER HEARING ABOUT THE TRANSMISSIONS DESTROYED WHEN THE DMF COMES APART, I SPENT $1,400.00 CDN TO REPLACE IT. IVE DRIVEN CLUTCHES ALL MY LIFE (33 YEARS) AND NEVER HAD TO REPLACE A CLUTCH BEFORE 200,000 MILES. *TR

Law Offices of Howard A. Gutman,
230 Route 206, Flanders, New Jersey 07836
(973) 598-1980, E-mail Howian@aol.com
Fax (973)598-1982

New York Office
305 Madison Avenue, Suite 449
New York, New York 10165 (212) 886-4838

FREE INITIAL CONSULTATION

We offer a free initial telephone consultation to discuss your lemon law case. Please feel free to call or e-mail our office.

Hit Counter

Keywords Volkswagen Jetta problem, lemon law, defect, lemon, problem, 2005 Volkswagen Jetta stalling problem, Volkswagen Jetta class action, lemon, vehicle problem, 2005 Volkswagen Jetta steering or alignment problem